Long Trip/City Maintenance Schedule Intervals
The services shown in this schedule up to 166 000 km (100,000 miles)
should be performed after 166 000 km (100,000 miles)
at the same intervals. The services shown in this schedule to be
performed at 240 000 km (150,000 miles) should
be performed after 240 000 km (150,000 miles)
at the same intervals.
For explanations of the maintenance inspections and services included
in this Maintenance Schedule, refer to
Explanation of Scheduled Services
.
For additional maintenance inspections and services which are not included
in this Maintenance Schedule, refer to
Periodic Maintenance Inspection
.
Footnotes
[Dagger] The U.S. Environmental Protection Agency or the California
Air Resources Board has determined that the failure to perform this maintenance
item will not nullify the emission warranty or limit recall liability
prior to the completion of the vehicle's useful life. We, however,
urge that all recommended maintenance services be performed at the
indicated intervals and the maintenance be recorded.
# Lubricate the chassis components with each engine oil and filter
change. Lubricate the front suspension, ball joints, steering linkage. transmission
shift linkage, transfer case shift linkage, parking brake cable guides,
and brake front axle. Ball joints should not be lubricated unless their
temperature is -12°C (10°F) or higher, or they could be
damaged.
+ A good time to check the brakes is during tire rotation. For
additional information on Brake System Inspection refer to
Periodic Maintenance Inspection
12 000 km (7,500 miles)
| • | Change the engine oil and filter -or 12 months,
whichever occurs first. |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components -or every 12 months,
whichever occurs first. |
| • | Check the rear/front axle fluid level and add fluid as needed.
Check the constant velocity joints and axle seals for leaking. |
24 000 km (15,000 miles)
| • | Change the engine oil and filter -or every 12 months,
whichever occurs first. |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components -or every 12 months,
whichever occurs first. # |
| • | Check the rear/front axle fluid level and add fluid as needed.
Check constant velocity joints and axle seals for leaking. |
| • | Replace the passenger compartment air filter, if equipped. |
| • | Inspect the shields and underhood for damage or looseness. Adjust
or replace as required. |
| | This is a Noise Emission Control Service.
Applicable only to vehicles sold in the United States. |
| • | Check the air intake system installation to assure that gaskets
are properly sealed and that all hose connections, fasteners and other components
are tight. Also check to be sure that the air cleaner housing is properly
seated and the cover fits tightly. Tighten connections and fasteners
or replace damaged parts as necessary. |
| | This is a Noise Emission
Control Service. Applicable only to vehicles sold in the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect
all hoses and ducts for proper hook-up -or every 12 months, whichever
occurs first. Be sure the valve works properly. |
| | This is
a Noise Emission Control Service. Applicable only to vehicles sold in the
United States. |
36 000 km (22,500 miles)
| • | Change engine oil and filter -or every 12 months,
whichever occurs first. |
| • | Lubricate chassis components -or every 12 months,
whichever occurs first. # |
| • | Check rear/front axle fluid level and add fluid as needed. Check
constant velocity joints and axle seals for leaking |
48 000 km (30,000 miles)
| • | Change the engine oil and filter -or every 12 months,
whichever occurs first. |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components -or every 12 months,
whichever occurs first. # |
| • | Check the rear/front axle fluid level and add fluid as needed.
Check constant velocity joints and axle seals for leaking. |
| • | Replace the passenger compartment air filter, if equipped. |
| • | Replace the fuel filter. |
| | This is an Emission Control
Service. [Dagger] |
| • | Inspect the shields and underhood insulation for damage or looseness.
Adjust or replace as required. |
| | This is a Noise Emission Control
Service. Applicable only to vehicles sold in the United States. |
| • | Check the air intake system installation to assure that gaskets
are properly sealed and that all hose connections, fasteners and other components
are tight. Also check to be sure that the air cleaner housing is properly
seated and the cover fits tightly. Tighten connections and fasteners
or replace damaged parts as necessary. |
| | This is a Noise Emission
Control Service. Applicable only to vehicles sold in the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect
all hoses and ducts for proper hook-up -or every 12 months, whichever
occurs first. Be sure the valve works properly. |
| | This is
a Noise Emission Control Service. Applicable only to vehicles sold in the
United States. |
60 000 km (37,500 miles)
| • | Change the engine oil and filter or every 12 months, whichever
occurs first. |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components or every 12 months, whichever
occurs first. # |
| • | Check the rear/front axle fluid level and add fluid as needed.
Check the constant velocity joints and axle seals for leaking. |
72 000 km (45,000 miles)
| • | Change the engine oil and filter -or every 12 months,
whichever occurs first. |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components -or every 12 months,
whichever occurs first. # |
| • | Check the rear/front axle fluid level and add fluid as needed.
Check the constant velocity joints and axle seals for leaking. |
| • | Replace the passenger compartment air filter, if equipped. |
| • | Inspect the shields and underhood insulation for damage or looseness.
Adjust or replace as required. |
| | This is a Noise Emission Control
Service. Applicable only to vehicles sold in the United States. |
| • | Check the air intake system installation to assure that gaskets
are properly sealed and that all hose connections, fasteners and other components
are tight. Also check to be sure that the air cleaner housing is properly
seated and the cover fits tightly. tighten connections and fasteners
or replace damaged parts as necessary. |
| | This is a Noise emission
Control Service. Applicable only to vehicles sold in the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect
all hoses and ducts for proper hook-up -or every 12 months, whichever
occurs first. Be sure the valve works properly. |
| | This is
a Noise Emission Control Service. Applicable to vehicles sold in the United
States. |
76 000 km (50,000 miles)
| • | Change automatic transmission fluid and filter. Manual transmission
fluid doesn't require change. |
| • | Change transfer case fluid. |
84 000 km (52,500 miles)
| • | Change engine oil and filter -or every 12 months,
whichever occurs first. |
| | This is an Emission Control Service. |
| • | Lubricate chassis components -or every 12 months,
whichever occurs first. # |
| • | Check rear/front axle fluid level and add fluid as needed. Check
constant velocity joints and axle seals for leaking. |
96 000 km (60,000 miles)
| • | Change the engine oil and filter -or every 12 months,
whichever occurs first. |
| | This is an Emission Control Service. |
| • | Lubricate chassis components -or every 12 months,
whichever occurs first. # |
| • | Check rear/front axle fluid level and add fluid as needed. Check
constant velocity joints and axle seals for leaking. |
| • | Replace passenger compartment air filter, if equipped. |
| • | Inspect the engine accessory drive belt. |
| | This is an
Emission Control Service. |
| • | Inspect the shields and underhood insulation for damage or looseness.
Adjust or replace as required. |
| | This is a Noise Emission control
Service. Applicable only to vehicles sold in the United States. |
| • | Check the air intake system installation to assure that gaskets
are properly sealed and that all hose connections, fasteners and other components
are tight. |
| | Also check to be sure that the air cleaner housing
is properly seated and the cover fits tightly. Tighten connections and fasteners
or replace damaged parts as necessary |
| | This is a Noise Emission
control Service. Applicable only to vehicles sold in the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect
all hoses and ducts for proper hook-up -or every 12 months, whichever
occurs first. Be sure the valve works properly. |
| | This is
a Noise Emission Control Service. Applicable only to vehicles sold in the
United States. |
| • | Replace the fuel filter. |
| | This is an Emission Control
Service. [Dagger] |
108 000 km (67,500 miles)
| • | Change the engine oil and filter -or every 12 months,
whichever occurs first. |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components -or every 12 months,
whichever occurs first. # |
| • | Check the rear/front axle fluid level and add fluid as needed.
Check the constant velocity joints and axle seals for leaking. |
120 000 km (75,000 miles)
| • | Change the engine oil and filter -or every 12 months,
whichever occurs first. |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components -or every 12 months,
whichever occurs first. # |
| • | Check the rear/front axle fluid level and add fluid as needed.
Check the constant velocity joints and axle seals for leaking. |
| • | Replace the passenger compartment air filter, if equipped. |
| • | Inspect the shields and underhood insulation for damage or looseness.
Adjust or replace as required. |
| | This is a Noise Emission Control
Service. Applicable only to vehicles sold in the United States. |
| • | Check the air intake system installation to assure that the gaskets
are properly sealed and that all hose connections, fasteners and other components
are tight. |
| | Also check to be sure that the air cleaner housing
is properly seated and the cover fits tightly. tighten connections and fasteners
or replace damaged parts as necessary. |
| | This is a Noise Emission
Control Service. Applicable only to vehicles sold in the United States. |
| • | If the engine has a thermostatically controlled cooling fan, inspect
all hoses and ducts for proper hook-up -or every 12 months, whichever
occurs first. Be sure the valve works properly. |
| | This is
a Noise Emission Control Service. Applicable only to vehicles sold in the
United States. |
132 000 km (82,500 miles)
| • | Change the engine oil and filter -or every 12 months,
whichever occurs first. # |
| • | Lubricate the chassis components -or every 12 months,
whichever occurs first. |
| • | Check the rear/front axle fluid level and add fluid as needed.
Check the constant velocity joints and axle seals for leaking. |
144 000 km (90,000 miles)
| • | Change the engine oil and filter -or every 12 months,
whichever occurs first. |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components -or every 12 months,
whichever occurs first. # |
| • | Check the rear/front axle fluid level and add fluid as needed.
Check the constant velocity joints and axle seals for leaking. |
| • | Replace passenger compartment air filter, if equipped. |
| • | Inspect the shields and underhood insulation for damage or looseness.
Adjust or replace as required. |
| | This is a Noise Emission Control
Service. Applicable only to vehicles sold in the United States. |
| • | Check the air intake system installation to assure that gaskets
are properly sealed and that all hose connections, fasteners and other components
are tight. |
| | Also check to be sure that the air cleaner housing
is properly seated and the cover fits tightly. Tighten connections and fasteners
or replace damage parts as necessary. |
| | This is a Noise Emission
Control Service. Applicable only to vehicles sold in the United States. |
| • | If the engine has a thermostatically controlled cooling fan,
inspect all hoses and ducts for proper hook-up -or every 12 months,
whichever occurs first. Be sure the valve works properly. |
| | This is a Noise Emission Control Service. Applicable only to vehicles sold
in the United States. |
| • | Replace the fuel filter. |
| | This is an Emission Control
Service. [Dagger] |
156 000 km (97,500 miles)
| • | Change the engine oil and filter -or every 12 months,
whichever occurs first. |
| | This is an Emission Control Service. |
| • | Lubricate the chassis components -or every 12 months,
whichever occurs first. # |
| • | Check the rear/front axle fluid level and add fluid as needed.
Check the constant velocity joints and axle seals for leaking. |
160 000 km (100,000 miles)
| • | Change the automatic transmission fluid and filter. Manual transmission
fluid doesn't require change. |
| • | Change transfer case fluid. |
240 000 km (150,000 miles)
| • | Drain, flush and refill the cooling system -or every 60 months
since the last service, whichever comes first. |
| • | Clean the following components. |
| • | Pressure test the cooling system and the pressure cap. |
| | This is an Emission Control Service. |
